Everything below concerns primary drying. We keep the language plain, cite what the science says, and separate well-supported claims from open questions.
Last reviewed on 2026-01-09. Where a claim depends on a specific study, the study is described rather than over-claimed.
Freezing is the first stage and sets the ice structure that later becomes the pore network. The formulation is cooled below its freezing point, often with a controlled ramp, and solutes concentrate as ice forms. Primary drying then lowers chamber pressure and supplies heat to sublime the ice. The product temperature must stay below its collapse or eutectic temperature to prevent structural loss. Secondary drying raises the temperature modestly to remove bound water and achieve a low residual moisture.
A freeze-dryer consists of a vacuum chamber, temperature-controlled shelves, a condenser, and a vacuum pump. Vials, ampoules, or bulk trays hold the product during the cycle. The condenser traps water vapor as ice at a temperature lower than the product. Cycle development balances shelf temperature, chamber pressure, and time. Scale-up can be difficult because heat and mass transfer change with equipment size, so process analytical tools and conservative validation are often used.
Misconceptions about lyophilization include the idea that dried products are indefinitely stable or that vacuum sealing eliminates all degradation. Chemical reactions can continue in the solid state, and some proteins lose activity even at low moisture. Another misconception is that any freeze-dryer cycle can be scaled by time alone; heat and mass transfer differ with equipment and load. Open questions remain about predicting long-term stability from short accelerated studies, particularly for amorphous formulations. Real-time stability data remain the standard for shelf-life assignment.
After lyophilization, the dried product is often sealed under vacuum or an inert gas to limit moisture and oxygen exposure. Vials, stoppers, and seals must maintain their barrier throughout shelf life. Storage temperature depends on product sensitivity: some cakes tolerate controlled room temperature, while labile biologics require refrigeration. Humidity is a critical variable because dried cakes are hygroscopic and can absorb water when exposed to air. Handling procedures therefore limit open-vial time and use desiccated environments for sampling.
Quality control for lyophilized materials examines appearance, reconstitution time, residual moisture, and mechanical integrity. An acceptable cake is usually uniform and porous, though appearance alone does not prove stability. Karl Fischer titration is a common method for water content, while differential scanning calorimetry can reveal glass transition events. Stability studies track potency, aggregation, and moisture over time under defined temperature and humidity conditions. Specifications are product-specific and may include sterility and endotoxin tests for sterile preparations.
| Property | Value | Notes |
|---|---|---|
| Common synonyms | freeze-drying, lyophilisation, cryodesiccation | Lyophilization is common in pharmaceutical literature. |
| Typical chamber pressure during primary drying | 0.05–0.5 mbar (5–50 Pa) | Must remain below the triple point of water. |
| Typical shelf temperature during freezing | −40 to −20 °C | Lower temperatures may be used for eutectic systems. |
| Typical residual moisture after secondary drying | 0.5–3% w/w | Product-dependent; low moisture improves stability but can cause over-drying. |
| Typical analytical method for residual moisture | Karl Fischer titration or loss on drying | Thermogravimetric methods are also used. |
A typical cycle begins with freezing, which fixes the material into a solid and determines ice crystal size. Primary drying then raises heat under vacuum so ice sublimes, often near or below the collapse temperature of the formulation. Secondary drying removes bound water that remains after ice is gone, usually by gently warming the product. Each stage balances heat input against pressure to avoid melting or structural damage. Temperature probes and pressure sensors guide the transition between stages.
In practice, lyophilization is slower and more energy intensive than simple drying. Cycle times can range from hours to several days depending on load, container, and formulation. Amorphous materials may require excipients that help preserve structure during freezing and drying. The method is widely used for biological materials, pharmaceuticals, and foods where heat drying would cause unacceptable change. Open questions remain about scaling cycles between laboratory and production equipment, and this gap affects technology transfer.
After drying, a lyophilized product is usually sealed under vacuum or an inert gas to limit moisture and oxygen exposure. The container closure system matters because stoppers and seals can allow moisture ingress over time. Storage conditions are selected from stability studies that track potency, cake appearance, and reconstitution behavior. Many freeze-dried materials are kept at controlled room temperature, while some require refrigeration or protection from light.
Quality control for freeze-dried forms includes visual inspection, water content measurement, and reconstitution time. A satisfactory cake is typically uniform, porous, and intact, although minor shrinkage or cracking may be acceptable if specifications allow. Karl Fischer titration, thermal gravimetric analysis, and near-infrared spectroscopy are used to measure water content. Reconstitution is assessed by adding a specified diluent and recording the time and ease of dissolution. Microbiological and particulate tests are added when the product is sterile or intended for injection.
In his widely awaited first speech since the start of the war in Gaza on 3 November, Hezbollah leader Hassan Nasrallah said the presence of U.S. warships in the Mediterranean "doesn't scare us". On 5 November, Hezbollah shot down an Israeli Elbit Hermes 450 drone over Nabatieh, with wreckage falling over houses in the towns of Zabdin and Harouf. One Israeli civilian was killed when anti-tank missiles hit the Yiftah kibbutz. Four people were reportedly injured after an Israeli bombing that hit two ambulances. Later, an Israeli airstrike hit two civilian cars in Lebanon between the towns of Aynata and Aitaroun, killing one woman, three of her granddaughters between the ages of 10 and 14, and severely injured her daughter. In response, Hezbollah fired at Kiryat Shmona, killing an Israeli civilian. The Al-Qassam Brigades took responsibility for firing 16 rockets from Lebanon targeting areas south of Haifa. Meanwhile, Israel reported at least 30 rockets being fired in which the IDF fired back at the sources. Hezbollah and Al-Qassam brigades also conducted four cross-border attacks into northern Israel. Hezbollah deputy general Naim Qassem said that the group could be forced into wider conflict over Israeli attacks in Gaza. On 10 November, Hezbollah launched anti-tank missiles into an IDF post in Manara which injured three soldiers. The IDF attacked the sources of fire in response. Hezbollah conducted three drone attacks into northern Israel targeting IDF positions and civilians. One drone was intercepted while two others landed on Israeli territory.
Anne Ephrussi studied biology at Harvard University in the Department of Biochemistry and Molecular Biology from where she graduated in 1979. She continued to do her PhD at the Massachusetts Institute of Technology (MIT) in the group of Susumu Tonegawa where she received her doctoral degree in 1985. Ephrussi performed postdoctoral research at Harvard University in the lab of Thomas Maniatis from 1986 to 1989 and at the Whitehead Institute for Biomedical Research with Ruth Lehmann from 1989 to 1992. Since 1992, Anne Ephrussi has been a group leader at the European Molecular Biology Laboratory (EMBL). She became the head of EMBL International Centre for Advanced Training in 2005. She served as Associate Dean (1999 - 2005) and Dean (2005 - 2008) of Graduate Studies of the EMBL International PhD program and as head of the developmental biology unit (2007-2021). She is part of numerous international Scientific Advisory Boards and Panels, organizes international conferences and scientific meetings and evaluates research grant and fellowship applications for a variety of renowned funding bodies.
date-range is the range of dates corresponding to the given confidence level confidence indicates the confidence level for the given date range. For example, "cal 1220–1281 AD (1σ)" means a calibrated date for which the true date lies between AD 1220 and AD 1281, with a confidence level of '1 sigma', or approximately 68%. Calibrated dates can also be expressed as "BP" instead of using "BC" and "AD". The curve used to calibrate the results should be the latest available IntCal curve. Calibrated dates should also identify any programs, such as OxCal, used to perform the calibration. In addition, an article in Radiocarbon in 2014 about radiocarbon date reporting conventions recommends that information should be provided about sample treatment, including the sample material, pretreatment methods, and quality control measurements; that the citation to the software used for calibration should specify the version number and any options or models used; and that the calibrated date should be given with the associated probabilities for each range.
=== Round-trip efficiency === The table below shows the result of an experimental evaluation of a "high-energy" type 3.0 Ah 18650 NMC cell in 2021, round-trip efficiency which compared the energy going into the cell and energy extracted from the cell from 100% (4.2v) SoC to 0% SoC (cut off 2.0v). A round-trip efficiency is the percent of energy that can be used relative to the energy that went into charging the battery.
The country had fielded black troops during World War I, but since then had retained them only within the BSAP. A nucleus of airmen existed in the form of the Southern Rhodesian Air Force (SRAF), which in August 1939 comprised one squadron of 10 pilots and eight Hawker Hardy aircraft, based at Belvedere Airport near Salisbury. The occupation of Czechoslovakia by Nazi Germany in March 1939 convinced Huggins that war was imminent. Seeking to renew his government's mandate to pass emergency measures, he called an early election in which his United Party won an increased majority. Huggins rearranged his Cabinet on a war footing, making the Minister of Justice Robert Tredgold Minister of Defence as well. The territory proposed forces not only for internal security but also for the defence of British interests overseas. Self-contained Rhodesian formations were planned, including a mechanised reconnaissance unit, but Tredgold opposed this. Remembering the catastrophic casualties suffered by units such as the Royal Newfoundland Regiment and the 1st South African Infantry Brigade on the Western Front in World War I, he argued that one or two heavy defeats for a white Southern Rhodesian brigade might cause crippling losses and have irrevocable effects on the country as a whole. He proposed to instead concentrate on training white Rhodesians for leadership roles and specialist units, and to disperse the colony's men across the forces in small groups. These ideas met with approval in both Salisbury and London and were adopted.
Sources: en.wikipedia.org
The three substrates of this enzyme are N-succinyl-L-glutamic 5-semialdehyde, oxidised nicotinamide adenine dinucleotide (NAD+), and water. Its products are N-succinyl-L-glutamic acid, reduced NADH, and a proton. This enzyme belongs to the family of oxidoreductases, specifically those acting on the aldehyde or oxo group of donor with NAD+ or NADP+ as acceptor. The systematic name of this enzyme class is N-succinyl-L-glutamate 5-semialdehyde:NAD+ oxidoreductase. Other names in common use include succinylglutamic semialdehyde dehydrogenase, N-succinylglutamate 5-semialdehyde dehydrogenase, SGSD, AruD, and AstD. This enzyme participates in arginine and proline metabolism.
==== Commander of the Royal Victorian Order (CVO) ==== The Lady Elizabeth Georgina Alice Cavendish, , Extra Lady in Waiting to The Princess Margaret, Countess of Snowdon. Richard Byron Caws, , lately Crown Estate Commissioner. Philip Stephen Gilbert, , Broadcaster. Sir George Trevor Holdsworth, Trustee, The Duke of Edinburgh's Award.
== Further reading == Barberis, Peter; McHugh, John; Tyldesley, Mike (1999). Encyclopedia of British and Irish Political Organizations. Pinter. p. 164. Boothroyd, David (2001). Politico's Guide to the History of British Political Parties. Politico's Publishing. p. 300. ISBN 1-902301-59-5. Perrin, David A. (2000). The Socialist Party of Great Britain: Politics, Economics and Britain's Oldest Socialist Party. Wrexham: Bridge Books. p. 123. ISBN 1-872424-80-5.
December 12, 2005: Law concerning the treatment of repeat offenses. March 23, 2006: Law concerning equal pay between women and men. March 31, 2006: Law for equal opportunities. April 4, 2006: Law strengthening the prevention and repression of violence within couples or committed against minors. July 24, 2006: Law concerning immigration and integration. January 31, 2007: Law aiming to promote equal access for women and men to electoral mandates and elective functions (mandatory parity for municipalities with more than 3,500 inhabitants and in regional executives; alternates for general councilors, both of different genders; reduced public aid for a political party in case of non-compliance with parity for legislative election candidacies). This law will be followed by the laws of February 26 and July 23, 2008, concerning the facilitation of equal access between women and men to certain mandates and elected functions, as well as to social and professional responsibilities. March 5, 2007: Law concerning the prevention of delinquency. March 14, 2007: Creation of "3919," a national telephone number for victims and witnesses of domestic violence. April 13, 2007: Decree concerning the methods of calculation and sharing of family allowances in the case of alternating residence of children at each parent's home and amending the Social Security Code (second part: Decrees in the Council of State). August 1, 2007: Law authorizing the ratification of the Council of Europe Convention on Action against Trafficking in Human Beings.
Sources: en.wikipedia.org
==== Dopamine receptor agonist ==== Some research suggests dopamine receptor agonists, most commonly pramipexole, may be effective in treating depression. Studies are few and results are preliminary, however.
Level instrumentation determines the height of liquids by measuring the position of a gas/liquid or liquid/liquid interface within the vessel or tank. Such interfaces include oil/gas, oil/water, condensate/water, glycol/condensate, etc. Local indication (LI) includes sight glasses which show the liquid level directly through a vertical glass tube attached to the vessel/tank. Phase interfaces are maintained at a constant level by level transmitters (LT) transmitting a signal to a level controller (LIC) which compares the measured value with the desired set point. The difference is sent as a signal to a level control valve (LCV) on the liquid outlet from the vessel. As the level rises the controller acts to open the valve to draw off liquid to reduce the level. Similarly as the levels fall the controller acts to close the LCV to reduce outflow of fluid. Some vessels store liquid until it is pumped out. The controller (LIC) acts to start and stop the pump within a specified band. For example, it may start the pump when the level rises to 0.6 m and stop the pump when the level falls to 0.4 m. High and low level alarms (LAH and LAL) warn operating personnel that levels are outside predefined limits. Further deviation (LAHH and LALL) initiates a shutdown either to close emergency shutdown valves (ESDV) on the inlet to the vessel or on the liquid outlet lines. As with high and low pressure instrumentation the shutdown function comprises an independent measurement loop to prevent a common mode failure.
== External links == "Relaxin Family Peptide Receptors: RXFP4". IUPHAR Database of Receptors and Ion Channels. International Union of Basic and Clinical Pharmacology. Archived from the original on 2016-03-03. Retrieved 2008-12-09.
Sources: en.wikipedia.org
Yes, the terms are generally interchangeable. Lyophilization is more common in pharmaceutical and laboratory contexts, while freeze-drying appears widely in food science and general writing. Both describe removal of solvent by sublimation under vacuum after freezing.
Reduced pressure keeps the process below the triple point of water, so ice can sublimate directly to vapor. It also lowers the temperature needed for drying, which helps preserve heat-sensitive materials. Without vacuum, melting or boiling could occur instead of controlled sublimation.
The rate depends on heat transfer to the product and mass transfer of vapor through the dried layer. A cold condenser, adequate vacuum, and suitable shelf temperature all influence speed. Formulation properties such as solid content and collapse temperature also set practical limits.
No. Freeze-drying removes water but does not reliably kill microorganisms. Sterile lyophilized products are typically prepared aseptically before freezing or are sterilized by a validated method. Microbial control depends on the entire manufacturing process.